基于粉管动压和煤粉分配的热态条件下中速磨煤机入口风量标定试验方法Calibration test method for inlet air volume of medium speed coal mill under hot conditions based on powder tube dynamic pressure and coal powder distribution
许积庄,沈志刚,沈娅芳,王洋,潘胜中,陈模,张钧玮
摘要(Abstract):
针对中速磨煤机输运介质特点及入口管路、空间等限制,冷态纯空气条件下的测试方法无法保证磨煤机入口风量标定测试及时性的问题,热态运行工况下,选取流场稳定的磨煤机出口管道,采用等截面网格法测试各粉管动压和煤粉分配特性,并用循环迭代法获取风粉混合物流速,最终以实测的磨煤机出口风粉混合物流量与煤量、设计密封风量的差值对磨煤机入口风量进行标定。试验结果表明,在相同的实测原始数据基础上,采用上述方法获取的磨煤机入口流量更接近真实值,准确性较采用冷态纯空气条件下的计算结果提升约15百分点。该方法测试简单,实操性强,可有效提升中速磨煤机入口风量标定结果的准确性和及时性,同时,对相似工业环境中含粉气流流量的测试也有一定的指导作用。
关键词(KeyWords): 中速磨煤机;风粉混合物;一次风量;电站锅炉
基金项目(Foundation): 国家电力投资集团有限公司科技项目(2023-KJ-005)~~
作者(Author): 许积庄,沈志刚,沈娅芳,王洋,潘胜中,陈模,张钧玮
DOI: 10.19666/j.rlfd.202401006
参考文献(References):
- [1]帅永,赵斌,蒋东方,等.中国燃煤高效清洁发电技术现状与展望[J].热力发电, 2022, 51(1):1-10.SHUAI Yong, ZHAO Bin, JIANG Dongfang, et al.Status and prospect of coal-fired high efficiency and clean power generation technology in China[J]. Thermal Power Generation, 2022, 51(1):1-10.
- [2]张全斌,周琼芳.基于“双碳”目标的中国火力发电技术发展路径研究[J].发电技术, 2023, 44(2):143-154.ZHANG Quanbin, ZHOU Qiongfang. Research on the development path of China’s thermal power generation technology based on the goal of “carbon peak and carbon neutralization”[J]. Power Generation Technology, 2023,44(2):143-154.
- [3]冯成凯,沈利,李金龙. HP1003型磨煤机灵活性改造研究[J].节能与环保, 2022(4):60-61.FENG Chengkai, SHEN Li, LI Jinlong. Modification of flexibility of HP1003 coal mill[J]. Energy Conservation and Environmental Protection, 2022(4):60-61.
- [4]张海龙,杨光锐,井新经,等.中速磨煤机直吹式制粉系统节能优化研究[J].华电技术, 2020, 42(6):25-30.ZHANG Hailong, YANG Guangrui, JING Xinjing, et al.Research on energy-saving optimization for medium-speed mill pulverizing systems[J]. Huadian Technology, 2020, 42(6):25-30.
- [5]刘家利,屠竞毅,方顺利,等.中速磨煤机在大型煤粉电站锅炉应用现状研究[J].热力发电, 2021, 50(3):19-26.LIU Jiali, TU Jingyi, FANG Shunli, et al. Application status of medium speed coal mill in large-scale coal-fired power plants[J]. Thermal Power Generation, 2021, 50(3):19-26.
- [6]王培萍,赵世伟,岳希明. ZGM113G型中速磨煤机运行问题分析[J].热力发电, 2010, 39(1):56-57.WANG Peiping, ZHAO Shiwei, YUE Ximing. Analysis of problems existing in operation of ZGM113G medium speed coal pulverizers[J]. Thermal Power Generation,2010, 39(1):56-57.
- [7]徐龙.中速磨直吹式制粉系统优化对锅炉经济性的影响[J].电站系统工程, 2020, 36(1):25-28.XU Long. Influence of medium speed mill direct-firing pulverizing system optimization on boiler economy[J].Power System Engineering, 2020, 36(1):25-28.
- [8]张海龙,李雯,张锋,等.中速磨煤机振动影响因素的研究[J].热力发电, 2023, 52(12):190-197.ZHANG Hailong, LI Wen, ZHANG Feng, et al.Research on influence factors of vibration of medium speed coal pulverizers[J]. Thermal Power Generation,2023, 52(12):190-197.
- [9]任衍辉,张振国.磨煤机制粉过程中的煤粉爆炸特性研究[J].吉林电力, 2018, 46(3):44-47.REN Yanhui, ZHANG Zhenguo. Study on explosion characteristics in coal pulverizing process for pulverizer[J]. Jilin Electric Power, 2018, 46(3):44-47.
- [10]丁建良,管诗骈,邹磊,等.制粉系统运行方式对锅炉NOx排放特性影响的试验研究[J].应用能源技术,2018(4):23-27.DING Jianliang, GUAN Shipian, ZOU Lei, et al. Effects of pulverizing system operation mode on NOx emission in boiler[J]. Applied Energy Technology, 2018(4):23-27.
- [11]柳行,姚著,王浩然.基于风煤比煤质校正的锅炉燃烧自动调整[J].热力发电, 2016, 45(8):75-80.LIU Hang, YAO Zhu, WANG Haoran. Auto combustion adjustment in boiler based on coal quality correction using air to coal radio[J]. Thermal Power Generation,2016, 45(8):75-80.
- [12]朱绘娟,王静杰,沈涛,等.褐煤锅炉风煤比对炉内燃烧特性影响的数值模拟研究[J].锅炉制造, 2022(6):4-5.ZHU Huijuan, WANG Jingjie, SHEN Tao, et al.Numerical simulation study on influence of primary air rate on combustion characteristics in lignite boiler[J].Boiler Manufacturing, 2022(6):4-5.
- [13]李波,弭尚文,王赫妍,等.燃煤锅炉直吹式制粉系统风量精确测量研究[J].沈阳工程学院学报(自然科学版), 2019, 15(1):35-39.LI Bo, MI Shangwen, WANG Heyan, et al. Research on accurate air flow measurement in direct pulverizing system of coal boiler[J]. Journal of Shenyang Institute of Engineering(Natural Science), 2019, 15(1):35-39.
- [14]陈献春,林旭,陈宇,等.大型燃煤机组中速磨煤机入口一次风量测量探析[J].电力与电工, 2011(1):15-18.CHEN Xianchun, LIN Xu, CHEN Yu, et al. Analysis for measurement of primary air quantity at entrances of medium speed mills of large coal-firing units[J]. Electric Power&Electrical Engineering, 2011(1):15-18.
- [15]兰斌.新型磨煤机一次风量测量装置的应用[J].华电技术, 2018, 40(3):57-58.LAN Bin. The application of a new measuring device for the primary air of pulverizer[J]. Huadian Technology,2018, 40(3):57-58.
- [16]顾志恩,林光锐,朱宝刚. 600 MW锅炉磨煤机入口一次风流量测量装置改造[J].电站系统工程, 2016,32(5):75-78.GU Zhien, LIN Guangrui, ZHU Baogang. Retrofit of PA flow measuring device at 600 MW boiler coal mill inlet[J]. Power System Engineering, 2016, 32(5):75-78.
- [17]肖凌涛,李军,周学忠.中速磨煤机入口一次风量测量误差的处理[J].热力发电, 2002(4):47-48.XIAO Lingtao, LI Jun, ZHOU Xuezhong. Elimination of inlet primary air low measurement error occurred on medium speed coal mills[J]. Thermal Power Generation,2002(4):47-48.
- [18]王佳茗,阎维平,李学颜,等.基于CFD数值计算的中速磨煤机进口风量测点选择[J].电力建设, 2011,32(1):1-4.WANG Jiaming, YAN Weiping, LI Xueyan, et al.Measurement position selection of inlet primary air flow rate for vertical-shaft mill based on CFD simulation[J].Electric Power Construction, 2011, 32(1):1-4.
- [19]房云龙,赵军,张小林.电站锅炉冷热一次风道改进及一次风流场均匀性分析[J].热能动力工程, 2019,34(11):59-68.FANG Yunlong, ZHAO Jun, ZHANG Xiaolin.Improvement of primary air duct and uniformity analysis of primary air flow field for a power plant boiler[J].Journal of Engineering for Thermal Energy and Power,2019, 34(11):59-68.
- [20]杜跃斐. HP中速磨煤机流场数值模拟分析[J].上海电气技术, 2021, 14(2):45-48.DU Yuefei. Numerical simulation analysis of flow field of HP medium-speed coal mill[J]. Shanghai Electrical Technology, 2021, 14(2):45-48.
- [21]王洋.华能烟台八角热电有限公司1号锅炉冷态空气动力场试验报告[R].西安:西安热工研究院有限公司, 2021:7-11.WANG Yang. Cold state aerodynamic field test report for boiler 1 of Huaneng Yantai Bajiao Thermal Power Co.,Ltd.[R]. Xi’an:Xi’an Thermal Power Research Institute Co., Ltd., 2021:7-11.
- [22]王亚欧,陈有福,管诗骈,等.超超临界二次再热机组锅炉冷态空气动力场试验浅析[J].锅炉技术, 2017,48(6):27-31.WANG Yaou, CHEN Youfu, GUAN Shipian, et al.Experimental research on boiler cold aerodynamic field of ultra-supercritical unit with double reheat cycles[J].Boiler Technology, 2017, 48(6):27-31.
- [23]电站锅炉性能试验规程:GB/T10184—2015[S].北京:中国标准出版社, 2016:60-61.Performance test code for utility boiler:GB/T10184—2015[S]. Beijing:Standards Press of China,2016:60-61.
- [24]张安国,梁辉.电站锅炉煤粉制备与计算[M].北京:中国电力出版社, 2010:199.ZHANG Anguo, LIANG Hui. Preparation and calculation of pulverized coal for utility boiler[M].Beijing:China Electric Power Press, 2010:199.
- [25]郭玉泉,郭磊.含尘气流密度的计算方法[J].广东电力, 2006, 19(10):20-21.GUO Yuquan, GUO Lei. Calculational methods of dusty airflow density[J]. Guangdong Electric Power, 2006,19(10):20-21.